DCR-SR77E, DCR-SR87, DCR-SR87E (serv.man2) - Sony Movie Service Manual (repair manual)

dcr-sr77e, dcr-sr87, dcr-sr87e (serv.man2) service manual
Model
DCR-SR77E DCR-SR87 DCR-SR87E (serv.man2)
Pages
73
Size
4.57 MB
Type
PDF
Document
Service Manual
Brand
Device
Movie / LEVEL 2
File
dcr-sr77e-dcr-sr87-dcr-sr87e-sm2.pdf
Date

Read Sony DCR-SR77E / DCR-SR87 / DCR-SR87E (serv.man2) Service Manual online

SERVICE MANUAL
Sony EMCS Co.
LEVEL
 
2
Link
SERVICE NOTE
MODEL INFORMATION TABLE
SPECIFICATIONS
FRAME SCHEMATIC DIAGRAM
BLOCK DIAGRAMS
DISASSEMBLY
PRINTED WIRING BOARDS
REPAIR PARTS LIST
SCHEMATIC DIAGRAMS
Link
DCR-SR77E/SR87/SR87E_L2
Photo: DCR-SR87
Revision History
Revision History
Ver. 1.3  2010.02
DIGITAL VIDEO CAMERA RECORDER
The components identified by
mark 0 or dotted line with
mark 0 are critical for safety.
Replace only with part num-
ber specified.
Les composants identifiés par une
marque  0  sont critiques pour la
sécurité.
Ne les remplacer que par une pièce
portant le numéro spécifié.
2010B0800-1
  © 2010.02
Published by Tokai TEC
9-852-637-34
• Precaution on Replacing the VC-554 Board
US Model
Canadian Model
AEP Model
UK Model
North European Model
E Model
Chinese Model
Korea Model
Argentine Model
Brazilian Model
Tourist Model
Japanese Model
DCR-SR77E/SR87/SR87E
Revised-1
Replace the previously issued
SERVICE MANUAL 9-852-637-33
with this Manual.
1-1
ENGLISH
JAPANESE
ENGLISH
JAPANESE
DCR-SR77E/SR87/SR87E_L2
1. SERVICE  NOTE
1-1. POWER  SUPPLY  DURING  REPAIRS
In this unit, about 10 seconds after power is supplied to the battery terminal using the regulated power supply (8.4 V), the power is shut off so
that the unit cannot operate.
These following method is available to prevent this.
Method:
Use the AC power adaptor (AC-L200C/L200D).
1-2. PRECAUTION  ON  REPLACING  THE  VC-554  BOARD
DESTINATION DATA
When you replace to the repairing board, the written destination data of repairing board also might be changed to original setting.
Start the Adjust Manual in the Adjust Station and execute the “DESTINATON DATA WRITE”.
RESTORE DATA
When you replace to the repairing board, get the data from the former one.
Start the Adjust Manual in the Adjust Station and perform “RESTORE DATA” to get the data.
The data getting for this model is as follows.
• USB SERIAL No.
USB SERIAL No.
The set is shipped with a unique ID (USB Serial No.) written in it.
This ID has not been written in a new board for service, and therefore it must be entered after the board replacement.
Start the Adjust Manual in the Adjust Station and execute the “USB SERIAL No. INPUT”.
1-3. USING  SERVICE  JIG
Connect the extension cable (J-6082-698-A) between CN1111 on the DA-044 board and CN1014 on the VC-554 board.
CN1111
CN1014
DA-044 board (side B)
VC-554 board (side B)
Extension cab
(J-6082-698-A)
le (100P)
— 2 —
ENGLISH
JAPANESE
ENGLISH
JAPANESE
DCR-SR77E/SR87/SR87E_L2
SPECIFICATIONS
These specifications are extracted from instruction manual of
DCR-SR77E/SR87E.
System
Signal format: PAL color, CCIR standards
Movie recording format
Video: MPEG2-PS
Audio: Dolby Digital 2ch/5.1ch Dolby Digital
5.1 Creator
Photo file format
: DCF Ver.2.0 Compatible
: Exif Ver.2.21 Compatible
: MPF Baseline Compatible
Recording media (Movie/Photo)
Hard disk: 80 GB
“Memory Stick PRO Duo” media
When measureing media capacity, 1 GB
equals 1 billion bytes, a portion of which is
used for data management.
Image device
3.0 mm (1/6 type) CCD (Charge Coupled
Device)
Gross: Approx. 1 070 000 pixels
Effective (Movie, 16:9): Approx. 670 000
pixels
Effective (Photos, 16:9): Approx. 750 000
pixels
Effective (Photos, 4:3): Approx. 1 000 000
pixels
Lens
Carl Zeiss Vario-Tessar
25
×(Optical), 50×, 2 000×(Digital)
Filter diameter: 30 mm (1 3/16 in.)
Focal length
F=1.8 ~ 3.2
f=2.5 ~ 62.5 mm (1/8 ~ 2 1/2 in.)
When converted to a 35 mm still camera
For movies: 41 ~ 1 189 mm (1 5/8 ~ 46 7/8
in.) (16:9)*
For photos: 36 ~ 900 mm (1 7/16 ~ 35 1/2
in.) (4:3)
Color temperature: [AUTO], [ONE PUSH],
[INDOOR] (3 200 K), [OUTDOOR] (5 800
K)
Minimum illumination
8 lx (lux) ([AUTO SLW SHUTTR] is set to
[ON], shutter speed 1/25 second)
*  The focal length figures are actual figures
 
resulting from wide angle pixel readout.
Input/Output connectors
A/V Remote Connector: Video/audio output jack
USB jack: mini-AB
(DCR-SR77E: output only)
LCD screen
Picture: 6.7 cm (2.7 type, aspect ratio 16:9)
Total number of pixels: 123 200 (560 
× 220)
General
Power requirements: DC 6.8 V/7.2 V (battery
pack) DC 8.4 V (AC Adaptor)
Average power consumption: During camera
recording, using LCD screen at normal
brightness:
Internal hard disc: 2.5 W
“Memory Stick PRO Duo” media: 2.3 W
Operating temperature: 0 ˚C to 40 ˚C (32 ˚F to
104 ˚F)
Storage temperature: -20 ˚C to +60 ˚C (-4 ˚F to
+140 ˚F)
Dimensions (approx.)
60 
× 68 × 105 mm (2 3/8 × 2 3/4 × 4 1/4 in.)
(w/h/d) including the projecting parts
60 
× 68 × 112 mm (2 3/8 × 2 3/4 × 4 1/2
in.) (w/h/d) including the projecting parts,
and the supplied rechargeable battery pack
attached
Mass (approx.)
300 g (10 oz) main unit only
350 g (12 oz) including the supplied
rechargeable battery pack
AC Adaptor AC-L200C/AC-L200D
Power requirements: AC 100 V - 240 V, 50 Hz/60
Hz
Current consumption: 0.35 A - 0.18 A
Power consumption: 18 W
Output voltage: DC 8.4 V*1
Operating temperature: 0 ˚C to 40 ˚C (32 ˚F to
104 ˚F)
Storage temperature: -20 ˚C to +60 ˚C (-4 ˚F to
+140 ˚F)
Dimensions (approx.): 48 
× 29 × 81 mm (1 15/16
 
× 1 3/16 × 3 1/4 in.) (w/h/d) excluding the
projecting parts
Mass (approx.): 170 g (6.0 oz) excluding the
power cord (mains lead)
*1 See the label on the AC Adaptor for other
     specifications.
Rechargeable battery pack
NP-FH50
Maximum output voltage: DC 8.4 V
Output voltage: DC 6.8 V
Maximum charge voltage: DC 8.4 V
Maximum charge current: 1.75 A
Capacity: 6.1 Wh (900 mAh)
Type: Li-ion
Design and specifications of your camcorder and
accessories are subject to change without notice.
— 3 —
ENGLISH
JAPANESE
ENGLISH
JAPANESE
DCR-SR77E/SR87/SR87E_L2
SPECIFICATIONS
These specifications are extracted from instruction manual of
DCR-SR87.
System
Signal format: NTSC color, EIA standards
Movie recording format
Video: MPEG2-PS
Audio: Dolby Digital 2ch/5.1ch Dolby Digital
5.1 Creator
Photo file format
: DCF Ver.2.0 Compatible
: Exif Ver.2.21 Compatible
: MPF Baseline Compatible
Recording media (Movie/Photo)
Hard disk: 80 GB
“Memory Stick PRO Duo” media
When measureing media capacity, 1 GB
equals 1 billion bytes, a portion of which is
used for data management.
Image device
3.0 mm (1/6 type) CCD (Charge Coupled
Device)
Gross: Approx. 1 070 000 pixels
Effective (Movie, 16:9): Approx. 670 000
pixels
Effective (Photos, 16:9): Approx. 750 000
pixels
Effective (Photos, 4:3): Approx. 1 000 000
pixels
Lens
Carl Zeiss Vario-Tessar
25
×(Optical), 50×, 2 000×(Digital)
Filter diameter: 30 mm (1 3/16 in.)
Focal length
F=1.8 ~ 3.2
f=2.5 ~ 62.5 mm (1/8 ~ 2 1/2 in.)
When converted to a 35 mm still camera
For movies: 41 ~ 1 189 mm (1 5/8 ~ 46 7/8
in.) (16:9)*
For photos: 36 ~ 900 mm (1 7/16 ~ 35 1/2
in.) (4:3)
Color temperature: [AUTO], [ONE PUSH],
[INDOOR] (3 200 K), [OUTDOOR] (5 800
K)
Minimum illumination
8 lx (lux) ([AUTO SLW SHUTTR] is set to
[ON], shutter speed 1/30 second)
*  The focal length figures are actual figures
  resulting from wide angle pixel readout.
Input/Output connectors
A/V Remote Connector: Video/audio output jack
USB jack: mini-AB
LCD screen
Picture: 6.7 cm (2.7 type, aspect ratio 16:9)
Total number of pixels: 123 200 (560 
× 220)
General
Power requirements: DC 6.8 V/7.2 V (battery
pack) DC 8.4 V (AC Adaptor)
Average power consumption: During camera
recording, using LCD screen at normal
brightness:
Internal hard disc: 2.5 W
“Memory Stick PRO Duo”  media: 2.3 W
Operating temperature: 0 ˚C to 40 ˚C (32 ˚F to
104 ˚F)
Storage temperature: -20 ˚C to +60 ˚C (-4 ˚F to
+140 ˚F)
Dimensions (approx.)
60 
× 68 × 105 mm (2 3/8 × 2 3/4 × 4 1/4 in.)
(w/h/d) including the projecting parts
60 
× 68  × 112 mm (2 3/8 × 2 3/4 × 4 1/2
in.) (w/h/d) including the projecting parts,
and the supplied rechargeable battery pack
attached
Mass (approx.)
300 g (10 oz) main unit only
350 g (12 oz) including the supplied
rechargeable battery pack
AC Adaptor AC-L200C/AC-L200D
Power requirements: AC 100 V - 240 V, 50 Hz/60
Hz
Current consumption: 0.35 A - 0.18 A
Power consumption: 18 W
Output voltage: DC 8.4 V*1
Operating temperature: 0 ˚C to 40 ˚C (32 ˚F to
104 ˚F)
Storage temperature: -20 ˚C to +60 ˚C (-4 ˚F to
+140 ˚F)
Dimensions (approx.): 48 
× 29 × 81 mm (1 15/16
 
× 1 3/16 × 3 1/4 in.) (w/h/d) excluding the
projecting parts
Mass (approx.): 170 g (6.0 oz) excluding the
power cord (mains lead)
*1 See the label on the AC Adaptor for other
specifications.
Rechargeable battery pack
NP-FH50
Maximum output voltage: DC 8.4 V
Output voltage: DC 6.8 V
Maximum charge voltage: DC 8.4 V
Maximum charge current: 1.75 A
Capacity: 6.1 Wh (900 mAh)
Type: Li-ion
Design and specifications of your camcorder and
accessories are subject to change without notice.
Page of 73

Download Sony DCR-SR77E / DCR-SR87 / DCR-SR87E (serv.man2) Service Manual (Repair Manual)

Here you can read online and download Sony DCR-SR77E / DCR-SR87 / DCR-SR87E (serv.man2) Service Manual in PDF. DCR-SR77E / DCR-SR87 / DCR-SR87E (serv.man2) service manual will guide through the process and help you recover, restore, fix, disassemble and repair Sony DCR-SR77E / DCR-SR87 / DCR-SR87E (serv.man2) Movie. Information contained in service manuals typically includes schematics / circuit diagrams, wiring diagrams, block diagrams, printed wiring boards, exploded views, parts list, disassembly / assembly, pcb.