Read Sony DPF-D75 / DPF-E75 Service Manual online
Ver.
Date
History
Contents
S.M.Rev
issued
DPF-D75/E75
Sony EMCS Co.
SERVICE MANUAL
Revision History
—
・
Correction of EXPLODED VIEWS
S.M. Revised:
Page 4
・
Correction of HOW TO CHANGE THE DESTINATION
S.M. Revised:
Page 6, 7
Official Release
Revision-1
Revision-1
A1 (09-523)
2010.01
2010.03
2010.03
1.0
1.1
1.1
—
Yes
Sony EMCS Co.
985276912.pdf
2010C2900-1
© 2010.3
Published by Tokai TEC
Ver. 1.1 2010.03
DIGITAL PHOTO FRAME
9-852-769-12
DPF-D75/E75
RMT-DPF5
US Model
Canadian Model
AEP Model
UK Model
East European Model
E Model
Russian Model
Australian Model
Chinese Model
Korea Model
Argentine Model
Brazilian Model
Japanese Model
Revised-1
Replacement of the previously issued
SERVICE MANUAL 9-852-769-11 with
this manual.
DPF-D75/E75
– 2 –
SPECIFICATIONS
概略仕様
– ENGLISH –
– JAPANESE –
x
本体
液晶画面
液晶パネル:
7.0型、TFT駆動
総ドット数:
1,152,000
(800×3(RGB)×480)ドット
有効表示画面
表示アスペクト比:
16:10
有効表示画面エリア:
6.8型
総ドット数:
1,105,920
(768×3(RGB)×480)ドット
液晶バックライト寿命
20,000時間
(バックライトの輝度が半減するまでの時間)
入出力端子
USB端子(TypeB、 Hi-Speed USB)
“メモリースティックPRO”(スタンダード
“メモリースティックPRO”(スタンダード
/デュオ)/SDメモリーカード/MMC/
xD-Picture Cardスロット
xD-Picture Cardスロット
表示可能なファイルフォーマット
JPEG:DCF 2.0準拠、Exif 2.21準拠、
JFIF
*1
TIFF:Exif 2.21準拠
BMP:1、4、8、16、24、32ビット
BMP:1、4、8、16、24、32ビット
Windows形式
RAW(簡易再生
*2
):
SRF、SR2、ARW(2.0まで)
画像の形式によっては、対応できないこと
があります。
があります。
最大再生画素数
8,000×6,000ドット
*3
ファイルシステム
FAT12/16/32、
セクタサイズ 2048バイト以下
画像ファイル名
DCF形式、128文字5階層以下
最大画像ファイル数
メモリーカード1枚につき4,999枚
内蔵メモリー容量
*4
256 MB
(保存ファイル数:約500枚
*5
)
電源 DC IN端子入力、DC5V
消費電力
消費電力
動作温度
5℃∼35℃
機種名
動作モード ACアダプター
含む
最大負荷時
6.6 W
通常モード
*
6.4 W
*
通常モードの定義は“出荷時設定にて内蔵メ
モリー内に保存したデータをスライド
モリー内に保存したデータをスライド
ショーしている状態でメモリーカードを取
り付けていない状態”です。
り付けていない状態”です。
外形寸法
(スタンドセット時)
約212 x 142 x 115.2 mm
(幅/高さ/奥行き)
(壁掛け時)
約212 x 142 x 39.3 mm
(幅/高さ/奥行き)
質量
約480 g
(ACアダプター含まず)
同梱品
・デジタルフォトフレーム
・スタンド
・リモコン
・ACアダプター
・取扱説明書
・デジタルフォトフレームハンドブック
・保証書
・カスタマー登録のご案内
x
AC アダプター
定格入力
AC100V - 240V、50/60Hz
0.3A
定格出力
DC 5V、2 A
外形寸法
約45×72×50mm
(幅/高さ/奥行き)
(最大突起部のぞく)
(最大突起部のぞく)
質量
約110 g(本体のみ)
その他の仕様については、ACアダプターのラベル
をご覧ください。
をご覧ください。
仕様および外観は、改良のため予告なく変更
することがあります。ご了承ください。
することがあります。ご了承ください。
*1
4:4:4、4:2:2、4:2:0形式のベースライン
JPEG
*2
RAWファイルサムネイルがそのまま表示され
ます。
ます。
*3
縦、横とも、17ドット以上ある必要があります。
縦横の比が20:1以上ある画像は正しく表示で
きない場合があります。
また、20:1以下でもサムネール表示や、スライド
ショーで表示されない場合があります。
縦横の比が20:1以上ある画像は正しく表示で
きない場合があります。
また、20:1以下でもサムネール表示や、スライド
ショーで表示されない場合があります。
*4
容量は、1MBを100万バイトで計算した場合の
数値です。また、管理用ファイル、アプリケーショ
ンなどをふくむため、実際に使用できる容量は減
少します。ご使用頂けるユーザー容量は、約
200MBです。
数値です。また、管理用ファイル、アプリケーショ
ンなどをふくむため、実際に使用できる容量は減
少します。ご使用頂けるユーザー容量は、約
200MBです。
*5
保存枚数は、200万画素相当の画像を保存した場
合の目安です。枚数は、
合の目安です。枚数は、
被写体および撮影条件に
よって異なります。
DPF-D75
x
Photo frame
LCD screen
LCD panel:
18cm/7.0-inch, TFT active matrix
Total number of dots:
1,152,000 (800 × 3(RGB) × 480) dots
Effective display area
Display aspect ratio: 16:10
LCD screen area:
17.3cm/6.8-inch
Total number of dots:
1,105,920 (768 × 3(RGB) × 480) dots
LCD backlight life
20,000 hours
(before brightness of the backlight is reduced
(before brightness of the backlight is reduced
to half)
Input/Output connectors
USB connector (TypeB, Hi-Speed USB)
Slots
Slots
“Memory Stick PRO” (Standard/Duo) / SD
memory card / MMC / xD-Picture Card slot
memory card / MMC / xD-Picture Card slot
Compatible image file formats
JPEG: DCF 2.0 compatible, Exif 2.21
compatible, JFIF
*1
TIFF: Exif 2.21 compatible
BMP: 1, 4, 8, 16, 24, 32 bit Windows format
RAW (preview only
BMP: 1, 4, 8, 16, 24, 32 bit Windows format
RAW (preview only
*2
) : SRF, SR2, ARW
(2.0 or lower version)
(Some image file formats are not
compatible.)
Maximum number of pixels that can be
displayed
8,000 (H) × 6,000 (V) dots
*3
File system
FAT12/16/32,
sector size of 2,048 bytes or smaller
Image file name
DCF format, 128 characters within 5th
hierarchy
Maximum number of files that can be
handled
4,999 files for a memory card
Internal memory capacity
*4
256 MB
(Approx. 500 images
*5
can be saved.)
Power requirements
DC IN jack, DC 5V
Power consumption
Operating temperature
5 °C to 35 °C (41 °F to 95 °F)
Model
in operation mode including the
AC adaptor
at the maximum load
6.6 W
normal mode*
6.4 W
* The definition of the normal mode is a status which
allows the performance of a slideshow using
images stored in the internal memory with the
default settings without inserting a memory card or
connecting an external device.
Dimensions
[With the stand spread out]
Approx. 212 × 142 × 115.2 mm
(8
(8
3
/
8
× 5
5
/
8
× 4
5
/
8
inches)
(width/height/depth)
[When the photo frame is hanging on the
wall]:
wall]:
Approx. 212 × 142 × 39.3 mm
(8
(8
3
/
8
× 5
5
/
8
× 1
9
/
16
inches)
(width/height/depth)
Mass
DPF-D75: Approx. 480 g (17 oz)
DPF-E75: Approx. 440 g (16 oz)
DPF-E75: Approx. 440 g (16 oz)
(excluding the AC adaptor)
Included accessories
·Digital photo frame
·Stand
·Remote control
·AC adaptor
·Exchangeable panels (DPF-E75 only)
·Operating Instructions
·CD-ROM (Digital Photo Frame Handbook)
·Warranty
·Stand
·Remote control
·AC adaptor
·Exchangeable panels (DPF-E75 only)
·Operating Instructions
·CD-ROM (Digital Photo Frame Handbook)
·Warranty
x
AC adaptor
Power requirements
- 100 V to 240 V, 50/60 Hz
0.3 A
0.3 A
Rated output voltage
5 V 2 A
Dimensions
Approx. 45 × 72 × 50 mm
(1
(1
13
/
16
× 2
7
/
8
× 2 inches)
(width/height/depth)
(excluding the protruding parts)
(excluding the protruding parts)
Mass
Approx. 110 g (4 oz)
See the label of AC adaptor for more details.
Design and specifications are subject to change
without notice.
without notice.
*1
: Baseline JPEG with 4:4:4, 4:2:2, or 4:2:0 format
*2
: RAW files are displayed as thumbnail preview.
*3
: 17 bits or more are required both vertically and
horizontally. An image with an aspect ratio of 20:1 or
more may not be displayed properly. Even if the
aspect ratio is less than 20:1, display problem may
occur in thumbnails, slideshow or other occasions.
more may not be displayed properly. Even if the
aspect ratio is less than 20:1, display problem may
occur in thumbnails, slideshow or other occasions.
*4
: The capacity is calculated as 1 MB is equivalent to
1,000,000 bytes. The actual capacity is reduced as
files for management and applications are included.
Approximately 200 MB can be used for your actual
operation.
files for management and applications are included.
Approximately 200 MB can be used for your actual
operation.
*5
: Approximate number is shown when the images
taken by 2,000,000 pixels equivalent camera are
saved. The value may vary depending on the shooting
condition.
saved. The value may vary depending on the shooting
condition.
DPF-D75 / E75
DPF-D75/E75
– 3 –
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH
MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST
ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPO-
NENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY
SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REM-
PLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT
LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES
SUPPLÉMENTS PUBLIÉS PAR SONY.
Unleaded solder
Boards requiring use of unleaded solder are printed with the leadfree
mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with the
lead free mark due to their particular size.)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40°C higher than ordi-
nary solder.
Ordinary soldering irons can be used but the iron tip has to be applied
to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to about
350°C.
Caution: The printed pattern (copper foil) may peel away if the heated
tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow) than
ordinary solder so use caution not to let solder bridges occur such as
on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may also be
added to ordinary solder.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety checks before releasing the set to the customer.
1. Check the area of your repair for unsoldered or poorly-soldered
connections. Check the entire board surface for solder splashes and
bridges.
2. Check the interboard wiring to ensure that no wires are “pinched”
or contact high-wattage resistors.
3. Look for unauthorized replacement parts, particularly transistors,
that were installed during a previous repair. Point them out to the
customer and recommend their replacement.
4. Look for parts which, through functioning, show obvious signs of
deterioration. Point them out to the customer and recommend their
replacement.
5. Check the B+ voltage to see it is at the values specified.
6. Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270°C during
repairing.
• Do not touch the soldering iron on the same conductor of the circuit
board (within 3 times).
• Be careful not to apply force on the conductor when soldering or
unsoldering.
1. 注意事項をお守りください。
サービスのとき特に注意を要する個所については,キャビ
ネット,シャーシ,部品などにラベルや捺印で注意事項を
表示しています。これらの注意書き及び取扱説明書等の注
意事項を必ずお守り下さい。
2. 指定部品のご使用を
セットの部品は難燃性や耐電圧など安全上の特性を持った
ものとなっています。従って交換部品は,使用されていた
ものと同じ特性の部品を使用して下さい。特に回路図,部
品表に0印で指定されている安全上重要な部品は必ず指定
のものをご使用下さい。
3. 部品の取付けや配線の引きまわしはもとどおりに
安全上,チューブやテープなどの絶縁材料を使用したり,
プリント基板から浮かして取付けた部品があります。また
内部配線は引きまわしやクランパによって発熱部品や高圧
部品に接近しないよう配慮されていますので,これらは必
ずもとどおりにして下さい。
4. サービス後は安全点検を
サービスのために取外したネジ,部品,配線がもとどおり
になっているか,またサービスした個所の周辺を劣化させ
てしまったところがないかなどを点検し,安全性が確保さ
れていることを確認して下さい。
5. チップ部品交換時の注意
・ 取外した部品は再使用しないで下さい。
・ タンタルコンデンサのマイナス側は熱に弱いため交換時
は注意して下さい。
6. フレキシブルプリント基板の取扱いについて
・ コテ先温度を270℃前後にして行なって下さい。
・ 同一パターンに何度もコテ先を当てないで下さい。
(3回以内)
・ パターンに力が加わらないよう注意して下さい。
サービス,点検時には次のことにご注意ください。
無鉛半田について
本機には無鉛半田が使用されています。
無鉛半田を使用している基板には,無鉛(Lead Free)を意味する
レッドフリーマークがプリントされています。
(
注意: 基板サイズによっては,無鉛半田を使用していてもレッ
ドフリーマークがプリントされていないものがありま
す)
:レッドフリーマーク
無鉛半田には,以下の特性があります。
・ 融点が従来の半田よりも約40℃高い。
従来の半田こてをそのまま使用することは可能ですが,少し
長めにこてを当てる必要があります。温度調節機能のついた
半田こてを使用する場合,約350℃に設定して下さい。
注意:半田こてを長く当てすぎると,基板のパターン(銅箔)
がはがれてしまうことがありますので,注意して下さ
い。
・ 粘性が強い
従来の半田よりも粘性が強いため,IC端子などが半田ブリッ
ジしないように注意して下さい。
・ 従来の半田と混ぜて使用可能
無鉛半田には無鉛半田を追加するのが最適ですが,従来の半
田を追加しても構いません。
– ENGLISH –
– JAPANESE –
MAIN FEATURES
主な特長
ソニーデジタルフォトフレームDPF-D75は,デジタルカメラな
どで撮影した画像を,コンピューターを使用せずに簡単にディ
スプレイに表示できるデジタルフォトフレームです。
• 様々なメモリーカードに対応
“ メモリースティック”,SD メモリーカード,xD-Picture
Card など様々なメモリーカードに対応しています。デジタル
カメラなどから抜いたメモリーカードをそのまま差し込むだ
けで,すぐに画像の表示ができます。
• 様々な表示機能
スライドショー,時計・カレンダー,一枚表示,インデック
スを色々なスタイルで表示できます。
• 多彩なスライドショー
まるでアルバムをめくるように,自動的に画像を切り換えて
表示します。時計やカレンダーをモチーフとしたスライド
ショーを含め,複数のスタイルから選べます。また,再生順
など,再生条件の設定ができます。
• 画像を内蔵メモリーに取り込む
メモリーカードの画像を内蔵メモリーに取り込むことができ
ます。
• 画像の書き出し
画像の書き出し機能により,内蔵メモリー内の画像をメモ
リーカードに書き出せます。
• 絞り込み機能
日付,フォルダー,縦写真/横写真,マークからお好みの画
像を絞り込むことができます。
• 縦置き,横置き自由自在
傾斜センサーにより,フレームの置きかた(縦置き,横置き)
に連動して,表示が自動的に回転します。
• 壁掛け対応
本機を壁掛けにしてお楽しみいただけます。
The Sony DPF-D75/E75 is a digital photo frame for easily displaying
images taken with a digital camera or other device, without using a
computer.
x
Support for various memory cards
Supports various memory cards, such as a “Memory Stick”, SD memory
card, and xD-Picture Card. Just insert a memory card removed from a
digital camera or other device, and you will be able to view the images
immediately.
x
Various display functions
You can enjoy various viewing modes, such as the slideshow display,
Clock and calendar display, Single view mode, and Index image
display.
x
Various slideshow styles
The displayed image can be switched automatically as though you are
turning the pages of an album yourself. You can select from various
slideshow styles, including the ones displaying a clock or calendar. You
can also change playback settings such as the playback order.
x
Importing images to internal memory
You can import and save the images in the internal memory.
x
Exporting images
You can export images in the internal memory to your memory card.
x
Sorting function
You can sort images by the date, folder, image direction, and mark.
x
Automatic rotation of images
The photo frame automatically rotates images to their proper orienta-
tion. Images are also automatically rotated when the photo frame is set
in either the portrait or landscape position.
x
Displaying images on a wall
You can hang the photo frame on the wall.
DPF-D75/E75
– 4 –
NOTE:
• -XX, -X mean standardized parts, so they may
have some differences from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
• The mechanical parts with no reference number
in the exploded views are not supplied.
SECTION 1
EXPLODED VIEWS
ns: not supplied
ns: not supplied
The components identified by mark 0
or dotted line with mark 0 are critical for
safety.
Replace only with part number specified.
Les composants identifiés par une marque
Les composants identifiés par une marque
0
sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
The components identified by mark 0 or
dotted line with mark 0 are critical for safety.
Replace only with part number specified.
Les composants identifiés par une marque
Les composants identifiés par une marque
0
sont critiques pour la sécurité.
Ne les remplacer que par une pièce portant
le numéro spécifié.
0
印の部品,または0印付の点線で囲ま
れた部品は,安全性を維持するために,
重要な部品です。
従って交換時は,必ず指定の部品を使用
してください。
0
印の部品,または0印付の点線で囲ま
れた部品は,安全性を維持するために,
重要な部品です。
従って交換時は,必ず指定の部品を使用
してください。
1-1. OVERALL SECTION
• Color Indication of Appearance Parts
Example:
(BLACK) : Cabinet’s Colo
(Black)
: Parts Color
• Abbreviation
AR : Argentine model
J
: Japanese model
AUS : Australian model
KR : Korea model
BR : Brazilian model
RUS : Russian model
CH : Chinese model
TW : Taiwan model
EE : East European model
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
1
A-1710-336-A FRONT COVER SERVICE (B) (BLACK)
1
A-1710-515-A FRONT COVER SERVICE (W) (WHITE)
1
A-1710-516-A FRONT COVER SERVICE (R) (RED)
1
A-1743-241-A FRONT COVER SERVICE (BQ) (CRYSTAL & BLACK)
1
A-1773-098-A FRONT COVER SERVICE (WZ) (CRYSTAL & WHITE)
2
1-811-163-11 LCD MODULE
3
4-186-855-01 SPONGE L, SERVICE
4
4-186-856-01 SPONGE S, SERVICE
5
3-080-206-21 SCREW, TAPPING, P2
6
A-1769-398-A REAR CASE ASSY SERVICE (BE)
(EXCEPT J (BLACK, RED))
6
A-1769-399-A REAR CASE ASSY SERVICE (BJ)
(J (BLACK, RED, CYSTAL & BLACK))
6
A-1769-400-A REAR CASE ASSY SERVICE (WE)
(EXCEPT J (WHITE))
6
A-1769-401-A REAR CASE ASSY SERVICE (WJ)
(J (WHITE, CYSTAL & WHITE))
7
3-080-206-21 SCREW, TAPPING, P2
(BLACK, RED, CYSTAL & BLACK)
7
7-685-103-14 SCREW +P 2X5 TYPE2 NON-SLIT
(WHITE, CRYSTAL & WHITE)
8
4-141-823-01 STAND
9
A-1774-935-A KEY PWB ASSY SERVICE (B)
(BLACK, RED, CYSTAL & BLACK)
9
A-1774-936-A KEY PWB ASSY SERVICE (W)
(WHITE, CRYSTAL & WHITE)
10
2-666-551-11 SCREW, TAPPING, P2
11
A-1769-402-A MAIN PWB ASSY SERVICE
12
4-141-820-01 SERVICE USB B CONNECTOR
13
1-798-321-11 SWITCH, TACTILE
0
14
4-141-818-01 SERVICE DC JACK
15
4-141-821-01 SERVICE FFC (KEY)
DPF-D75
Ref. No.
Part No.
Description
Ref. No.
Part No.
Description
1
4-176-428-01 EXCHANGEABLE FRAME (B) (BLACK (Black))
1
4-176-428-11 EXCHANGEABLE FRAME (R) (BLACK (Red))
1
4-176-428-21 EXCHANGEABLE FRAME (T) (BLACK (Blown))
1
4-176-428-31 EXCHANGEABLE FRAME (W) (WHITE (White))
1
4-176-428-41 EXCHANGEABLE FRAME (MG) (WHITE (Moss Green))
1
4-176-428-51 EXCHANGEABLE FRAME (BE) (WHITE (Beige))
2
A-1769-396-A FRONT COVER SERVICE (B) (BLACK)
2
A-1769-397-A FRONT COVER SERVICE (W) (WHITE)
3
1-811-163-11 LCD MODULE
4
3-080-206-21 SCREW, TAPPING, P2
5
A-1769-398-A REAR CASE ASSY SERVICE (BE) (BLACK)
5
A-1769-400-A REAR CASE ASSY SERVICE (WE) (WHITE)
6
3-080-206-21 SCREW, TAPPING, P2 (BLACK)
6
7-685-103-14 SCREW +P 2X5 TYPE2 NON-SLIT (WHITE)
7
4-141-823-01 STAND
8
A-1774-935-A KEY PWB ASSY SERVICE (B) (BLACK)
8
A-1774-936-A KEY PWB ASSY SERVICE (W) (WHITE)
9
2-666-551-11 SCREW, TAPPING, P2
10
A-1772-268-A MAIN PWB ASSY SERVICE
11
4-141-820-01 SERVICE USB B CONNECTOR
12
1-798-321-11 SWITCH, TACTILE
0
13
4-141-818-01 SERVICE DC JACK
14
4-141-821-01 SERVICE FFC (KEY)
DPF-E75
The changed portions from
Ver.1.0 are shown in blue.
Ver.1.1 2010.03
ns
ns
ns
3
4 4
14
9
13
12
11
8
5
6
7
10
1 2
ns
2(Claw)
ns
ns
ns
ns
2
5
3
4
4
5
15
10
14
13
12
9
6
7
8
11
1
ns
1(Claw)
3