Read Sony DCR-TRV240E / DCR-TRV340E (serv.man5) Service Manual online
SERVICE MANUAL
M2000 MECHANISM
DIGITAL VIDEO CAMERA RECORDER
SPECIFICATIONS
Photo : DCR-TRV240E
— Continued on next page —
DCR-TRV240E/TRV340E
RMT-814
AEP Model
UK Model
East European Model
North European Model
Russian Model
Level 1
Ver 1.1 2002. 06
Input/output
connectors
connectors
S video input/output
4-pin mini DIN
Luminance signal: 1 Vp-p,
75
4-pin mini DIN
Luminance signal: 1 Vp-p,
75
Ω
(ohms), unbalanced
Chrominance signal: 0.3 Vp-p,
75
75
Ω
(ohms), unbalanced
Audio/Video input/output
AV MINIJACK, 1 Vp-p, 75
AV MINIJACK, 1 Vp-p, 75
Ω
(ohms), unbalanced, sync negative
327 mV, (at output impedance more
than 47 k
327 mV, (at output impedance more
than 47 k
Ω
(kilohms))
Output impedance with less than
2.2 k
2.2 k
Ω
(kilohms)/Stereo minijack
(ø 3.5 mm)
Input impedance more than 47 k
Input impedance more than 47 k
Ω
(kilohms)
Headphone jack
Stereo minijack (ø 3.5 mm)
USB jack
mini-B
LANC jack
Stereo mini-minijack (ø 2.5 mm)
MIC jack
Stereo minijack (ø 3.5 mm)
DV input/output
4-pin connector
Headphone jack
Stereo minijack (ø 3.5 mm)
USB jack
mini-B
LANC jack
Stereo mini-minijack (ø 2.5 mm)
MIC jack
Stereo minijack (ø 3.5 mm)
DV input/output
4-pin connector
LCD screen
Picture
6.2 cm (2.5 type)
50.3
6.2 cm (2.5 type)
50.3
×
37.4 mm (2
×
1 1/2 in.)
Total dot number
For European models:
123 200 (560
For European models:
123 200 (560
×
220)
For other countries’ models:
61 600 (280
61 600 (280
×
220)
Video camera
recorder
recorder
System
Video recording system
2 rotary heads
Helical scanning system
Audio recording system
Rotary heads, PCM system
Quantization: 12 bits (Fs 32 kHz,
stereo 1, stereo 2), 16 bits
(Fs 48 kHz, stereo)
Video signal
PAL colour, CCIR standards
Recommended cassette
Hi8/Digital8 video cassette
Recording/playback time (using
90 min. Hi8 video cassette)
SP mode: 1 hour
LP mode: 1 hour and 30 minutes
Fast-forward/rewind time (using
90 min. Hi8 video cassette)
Approx. 5 min.
Viewfinder
Electric Viewfinder, Monochrome
Image device
3 mm (1/6 type CCD)
(Charge Coupled Device)
Gross: Approx. 800 000 pixels
Effective: Approx. 400 000 pixels
Lens
Combined power zoom lens
Filter diameter 37 mm (1 1/2 in.)
25
2 rotary heads
Helical scanning system
Audio recording system
Rotary heads, PCM system
Quantization: 12 bits (Fs 32 kHz,
stereo 1, stereo 2), 16 bits
(Fs 48 kHz, stereo)
Video signal
PAL colour, CCIR standards
Recommended cassette
Hi8/Digital8 video cassette
Recording/playback time (using
90 min. Hi8 video cassette)
SP mode: 1 hour
LP mode: 1 hour and 30 minutes
Fast-forward/rewind time (using
90 min. Hi8 video cassette)
Approx. 5 min.
Viewfinder
Electric Viewfinder, Monochrome
Image device
3 mm (1/6 type CCD)
(Charge Coupled Device)
Gross: Approx. 800 000 pixels
Effective: Approx. 400 000 pixels
Lens
Combined power zoom lens
Filter diameter 37 mm (1 1/2 in.)
25
×
(Optical), 700
×
(Digital)
Focal length
2.4 – 60 mm (1/8 – 2 3/8 in.)
When converted to a 35 mm still
camera
46 – 1 150 mm (1 13/16 – 45 3/8 in.)
2.4 – 60 mm (1/8 – 2 3/8 in.)
When converted to a 35 mm still
camera
46 – 1 150 mm (1 13/16 – 45 3/8 in.)
Colour temperature
Auto
Minimum illumination
6 lx (lux) (F 1.6)
0 lx (lux) (in the NightShot mode)*
* Objects unable to be seen due to
Auto
Minimum illumination
6 lx (lux) (F 1.6)
0 lx (lux) (in the NightShot mode)*
* Objects unable to be seen due to
the dark can be shot with infrared
lighting.
lighting.
General
Power requirements
7.2 V (battery pack)
8.4 V (AC power adaptor)
Average power consumption
(when using the battery pack)
During camera recording using
LCD
3.8 W
Viewfinder
3.0 W
Operating temperature
0
7.2 V (battery pack)
8.4 V (AC power adaptor)
Average power consumption
(when using the battery pack)
During camera recording using
LCD
3.8 W
Viewfinder
3.0 W
Operating temperature
0
°
C to 40
°
C (32
°
F to 104
°
F)
Recommended charging
temperature
10
temperature
10
°
C to 30
°
C (50
°
F to 86
°
F)
Storage temperature
–20
–20
°
C to + 60
°
C (–4
°
F to + 140
°
F)
Dimensions (approx.)
206
206
×
101
×
85 mm
(8 1/8
×
4
×
3 3/8 in.)
(w/h/d)
Mass (approx.)
DCR-TRV240E:
890 g (1 lb 15 oz)
DCR-TRV340E:
900 g (1 lb 15 oz)
excluding the battery pack, cassette,
lens cap and shoulder strap
DCR-TRV240E:
1 030 g (2 lb 4 oz)
DCR-TRV340E:
1 040 g (2 lb 4 oz)
including the battery pack
NP-FM30, 90min. Hi8 cassette, lens
cap and shoulder strap
Supplied accessories
See page 3.
DCR-TRV240E:
890 g (1 lb 15 oz)
DCR-TRV340E:
900 g (1 lb 15 oz)
excluding the battery pack, cassette,
lens cap and shoulder strap
DCR-TRV240E:
1 030 g (2 lb 4 oz)
DCR-TRV340E:
1 040 g (2 lb 4 oz)
including the battery pack
NP-FM30, 90min. Hi8 cassette, lens
cap and shoulder strap
Supplied accessories
See page 3.
AC power adaptor
Power requirements
100 – 240 V AC, 50/60 Hz
Power consumption
23 W
Output voltage
DC OUT: 8.4 V, 1.5 A in the
operating mode
Operating temperature
0
100 – 240 V AC, 50/60 Hz
Power consumption
23 W
Output voltage
DC OUT: 8.4 V, 1.5 A in the
operating mode
Operating temperature
0
°
C to 40
°
C (32
°
F to 104
°
F)
Storage temperature
–20
–20
°
C to + 60
°
C (–4
°
F to + 140
°
F)
Dimensions (approx.)
125
125
×
39
×
62 mm
(5
×
1 9/16
×
2 1/2 in. ) (w/h/d)
excluding projecting parts
Mass (approx.)
280 g (9.8 oz)
excluding mains lead
Mass (approx.)
280 g (9.8 oz)
excluding mains lead
2. GENERAL will be issued shortly.
— 2 —
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK
0
OR DOTTED LINE WITH
MARK
0
ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
DCR-TRV240E/TRV340E
1.
Check the area of your repair for unsoldered or poorly-soldered
connections. Check the entire board surface for solder splashes
and bridges.
connections. Check the entire board surface for solder splashes
and bridges.
2.
Check the interboard wiring to ensure that no wires are
"pinched" or contact high-wattage resistors.
"pinched" or contact high-wattage resistors.
3.
Look for unauthorized replacement parts, particularly
transistors, that were installed during a previous repair. Point
them out to the customer and recommend their replacement.
transistors, that were installed during a previous repair. Point
them out to the customer and recommend their replacement.
4.
Look for parts which, through functioning, show obvious signs
of deterioration. Point them out to the customer and
recommend their replacement.
of deterioration. Point them out to the customer and
recommend their replacement.
5.
Check the B+ voltage to see it is at the values specified.
6.
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270˚C
during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
Unleaded solder
Boards requiring use of unleaded solder are printed with the lead-
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40°C higher than
• Unleaded solder melts at a temperature about 40°C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350°C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350°C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow) than
ordinary solder so use caution not to let solder bridges occur such
as on IC pins, etc.
ordinary solder so use caution not to let solder bridges occur such
as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
also be added to ordinary solder.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety checks before releasing the set to the customer.
CAUTION :
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type.
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type.
Battery pack
Maximum output voltage
DC 8.4 V
Mean output voltage
DC 7.2 V
Capacity
5.0 Wh (700 mAh)
Operating temperature
0
DC 8.4 V
Mean output voltage
DC 7.2 V
Capacity
5.0 Wh (700 mAh)
Operating temperature
0
°
C to 40
°
C (32
°
F to 104
°
F)
Dimensions (approx.)
38.2
38.2
×
20.5
×
55.6 mm
(1 9/16
×
13/16
×
2 1/4 in.)
(w/h/d)
Mass (approx.)
65 g (2.3 oz)
Type
Lithium ion
Mass (approx.)
65 g (2.3 oz)
Type
Lithium ion
“Memory Stick”
(DCR-TRV340E only)
Memory
Flash memory
8MB: MSA-8A
Operating voltage
2.7 – 3.6 V
Power consumption
Approx. 45 mA in the operating
mode
Approx. 130
Flash memory
8MB: MSA-8A
Operating voltage
2.7 – 3.6 V
Power consumption
Approx. 45 mA in the operating
mode
Approx. 130
µ
A in the standby
mode
Dimensions (approx.)
50
Dimensions (approx.)
50
×
2.8
×
21.5 mm
(2
×
1/8
×
7/8 in.) (w/h/d)
Mass (approx.)
4 g (0.14 oz)
4 g (0.14 oz)
Design and specifications are
subject to change without notice.
subject to change without notice.
— 3 —
DCR-TRV240E/TRV340E
Checking supplied accessories.
Make sure that the following accessories are supplied with your camcorder.
3-072-651-11 MANUAL, INSTRUCTION (ENGLISH/RUSSIAN)
(TRV240E:UK,RU)
3-072-651-21 MANUAL, INSTRUCTION (FRENCH/GERMAN)
(TRV240E:AEP)
3-072-651-61 MANUAL, INSTRUCTION (ENGLISH DUTCH)
(TRV240E:AEP)
3-072-651-71 MANUAL, INSTRUCTION (SPANISH/PORTUGUESE)
(TRV240E:AEP)
3-072-651-81 MANUAL, INSTRUCTION (ITALIAN/GREEK)
(TRV240E:AEP)
3-072-651-91 MANUAL, INSTRUCTION (ENGLISH/SWEDISH)
(TRV240E:NE)
3-072-652-11 MANUAL, INSTRUCTION (DANISH/FINNISH)
(TRV240E:NE)
3-072-652-21 MANUAL, INSTRUCTION (POLISH/CZECH)(TRV240E:EE)
3-072-652-31 MANUAL, INSTRUCTION (HUNGARIAN/SLOVAKIAN)
3-072-652-31 MANUAL, INSTRUCTION (HUNGARIAN/SLOVAKIAN)
(TRV240E:EE)
Wireless Remote Commander (1)
RMT-814
1-475-141-61
RMT-814
1-475-141-61
AC power adaptor (1)
(AC-L10A)
(AC-L10A)
0
1-475-599-11
R6 (Size AA) battery for
Remote Commander (2)
(not supplied)
Remote Commander (2)
(not supplied)
A/V connecting cable (1.5m) (1)
1-765-080-11
1-765-080-11
21-pin adaptor (1)
1-573-291-11
1-573-291-11
Lens cap (1)
X-3949-376-1
X-3949-376-1
USB cable (1)
1-757-293-21
1-757-293-21
CD-ROM
(SPVD-008(P) USB Driver)(1)
3-072-414-01
(SPVD-008(P) USB Driver)(1)
3-072-414-01
Power cord (Main lead)(1)
(AEP, EE, NE, RU model)
(AEP, EE, NE, RU model)
0
1-769-608-11
Power cord (Main lead)(1)
(UK model)
(UK model)
0
1-783-374-11
NP-FM30 battery pack (1)
(Not supplied)
(Not supplied)
Memory stick (1)
MSA-8A
A-7024-735-A
(DCR-TRV340E only)
MSA-8A
A-7024-735-A
(DCR-TRV340E only)
Shoulder strap (1)
3-987-015-01
3-987-015-01
Other accessories
3-072-653-11 MANUAL, INSTRUCTION (ENGLISH/RUSSIAN)
(TRV340E:UK,RU)
3-072-653-21 MANUAL, INSTRUCTION (FRENCH/GERMAN)
(TRV340E:AEP)
3-072-653-31 MANUAL, INSTRUCTION (ENGLISH DUTCH)
(TRV340E:AEP)
3-072-653-41 MANUAL, INSTRUCTION (SPANISH/PORTUGUESE)
(TRV340E:AEP)
3-072-653-51 MANUAL, INSTRUCTION (ITALIAN/GREEK)
(TRV340E:AEP)
3-072-653-61 MANUAL, INSTRUCTION (ENGLISH/SWEDISH)
(TRV340E:NE)
3-072-653-71 MANUAL, INSTRUCTION (DANISH/FINNISH)
(TRV340E:NE)
3-072-653-81 MANUAL, INSTRUCTION (POLISH/CZECH)(TRV340E:EE)
3-072-653-91 MANUAL, INSTRUCTION (HUNGARIAN/SLOVAKIAN)
3-072-653-91 MANUAL, INSTRUCTION (HUNGARIAN/SLOVAKIAN)
(TRV340E:EE)
Note :
The components identified by mark
0
or dotted
line with mark
0
are critical for safety.
Replace only with part number specified.
• Abbreviation
EE
: East European model
NE
: North European model
RU
: Russian model
— 4 —
DCR-TRV240E/TRV340E
TABLE OF CONTENTS
SERVICE NOTE
1.
POWER SUPPLY DURING REPAIRS ····························· 5
2.
TO TAKE OUT A CASSETTE WHEN NOT EJECT
(FORCE EJECT) ································································ 5
(FORCE EJECT) ································································ 5
SELF-DIAGNOSIS FUNCTION
1.
Self-diagnosis Function ······················································ 6
2.
Self-diagnosis Display ························································ 6
3.
Service Mode Display ························································ 6
3-1.
Display Method ·································································· 6
3-2.
Switching of Backup No. ··················································· 6
3-3.
End of Display ···································································· 6
4.
Self-diagnosis Code Table ·················································· 7
1.
MAIN PARTS
1.
ORNAMENTAL PARTS ···················································· 9
2.
DISASSEMBLY ······························································· 10
2-1.
LCD UNIT, PD-156 BOARD ·········································· 11
2-2.
FRONT PANEL SECTION, SI-032 BOARD ·················· 12
2-3.
CABINET (R) SECTION ················································ 13
2-4.
LENS SECTION, CD-357 BOARD ································ 14
2-5.
EVF SECTION, LB-076 BOARD ··································· 14
2-6.
BATTERY PANEL SECTION, BATTERY TERMINAL
BOARD ············································································ 15
BOARD ············································································ 15
2-7.
MEMORY STICK 10P CONNECTOR
(MEMORY STICK MODEL) (TRV340E) ······················ 15
(MEMORY STICK MODEL) (TRV340E) ······················ 15
2-8.
CONTROL SWITCH BLOCK (SS-1380) ······················· 16
2-9.
CABINET (L) SECTION, CS FRAME ASSEMBLY (25) · 16
2-10. VC-276 BOARD ······························································ 17
2-11. MECHANISM DECK ······················································ 17
2-12. CONTROL SWITCH BLOCK (CF-2500) ······················ 18
2-13. CONTROL SWITCH BLOCK (FK-2500) ······················ 18
2-14. HINGE SECTION ···························································· 19
3.
2-11. MECHANISM DECK ······················································ 17
2-12. CONTROL SWITCH BLOCK (CF-2500) ······················ 18
2-13. CONTROL SWITCH BLOCK (FK-2500) ······················ 18
2-14. HINGE SECTION ···························································· 19
3.
REPAIR PARTS LIST ······················································ 20
3-1.
EXPLODED VIEWS ······················································· 20
3-1-1. OVERALL SECTION ······················································ 20
3-1-2. CABINET (L) SECTION-1 ············································· 21
3-1-3. CABINET (L) SECTION-2 ············································· 22
3-1-4. LENS, EVF SECTION ····················································· 23
3-1-5. CABINET (R) SECTION ················································ 24
3-1-6. LCD SECTION ································································ 25
3-1-2. CABINET (L) SECTION-1 ············································· 21
3-1-3. CABINET (L) SECTION-2 ············································· 22
3-1-4. LENS, EVF SECTION ····················································· 23
3-1-5. CABINET (R) SECTION ················································ 24
3-1-6. LCD SECTION ································································ 25
2.
GENERAL
2. GENERAL will be issued shortly.
