Read Sony DSC-P52 (serv.man3) Service Manual online
SERVICE MANUAL
DIGITAL STILL CAMERA
Revision History
Revision History
Ver 1.0 2003. 03
LEVEL
1
DSC-P52
US Model
Canadian Model
AEP Model
UK Model
E Model
Australian Model
Hong Kong Model
Korea Model
Chinese Model
Tourist Model
Brazilian Model
• INSTRUCTION MANUAL is shown at the end of this document.
Link
SELF DIAGNOSIS FUNCTION
ORNAMENTAL PARTS
SPECIFICATIONS
SELF DIAGNOSIS FUNCTION
ORNAMENTAL PARTS
SPECIFICATIONS
Link
— 2 —
DSC-P52
SPECIFICATIONS
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH
MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!
LES COMPOSANTS IDENTIFÉS PAR UNE MARQUE 0 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE
REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY
DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE
REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY
DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU
DANS LES SUPPÉMENTS PUBLIÉS PAR SONY.
COVER
COVER
CAUTION :
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type.
Danger of explosion if battery is incorrectly replaced.
Replace only with the same or equivalent type.
Recording media
“Memory Stick”
Flash
Recommended distance
[Output connectors]
A/V OUT (MONO) jack (Monaural)
Minijack
Video: 1 Vp-p, 75
Video: 1 Vp-p, 75
Ω
, unbalanced,
sync negative
Audio: 327 mV (at a 47 k
Audio: 327 mV (at a 47 k
Ω
load)
Output impedance 2.2 k
Ω
USB jack
mini-B
[LCD screen]
LCD panel used
4.0 cm (1.6 type) TFT drive
Total number of dots
61 600 (280
×
220) dots
[Power, general]
Power
AA nickel hydride batteries (2)
2.4 V
AC-LS5 AC Adaptor
(not supplied), 4.2 V
2.4 V
AC-LS5 AC Adaptor
(not supplied), 4.2 V
Power consumption (when recording)
1.6W
Operating temperature range
0
°
to +40
°
C (32
°
to +104
°
F)
Storage temperature range
–20
°
to +60
°
C (–4
°
to +140
°
F)
Dimensions
Mass
Microphone
Electret condenser microphone
Speaker
Dynamic speaker
x BC-CS2A/CS2B Ni-MH battery
charger
Power requirements
AC 100 to 240V 50/60Hz
3 W
3 W
Output voltage
AA : DC 1.4 V 400 mA
×
2
AAA : DC 1.4 V 160 mA
×
2
Operating temperature range
0
°
to +40
°
C (32
°
to +104
°
F)
Dimensions
71
×
30
×
91 mm
(2
7
/
8
×
1
3
/
16
×
3
5
/
8
inches) (W/H/
D)
Mass
Approx. 90 g (3 oz)
x AC-LS5 AC Adaptor (not supplied)
Power requirements
AC 100 to 240 V, 50/60 Hz
11 W 0.16 to 0.09 A
11 W 0.16 to 0.09 A
Rated output voltage
DC 4.2 V, 1.5 A
Operating temperature range
0
°
to +40
°
C (32
°
to +104
°
F)
Storage temperature range
–20
°
to +60
°
C (–4
°
to +140
°
F)
Dimensions
48
×
29
×
81 mm (1
15
/
16
×
1
3
/
16
3
1
/
4
inches) (W/H/D, protruding
parts not included)
Mass
Approx. 180 g (6 oz)
(adaptor only)
(adaptor only)
Accessories
HR6 (size AA) Ni-MH batteries (2)
Battery
case
BC-CS2A/CS2B Ni-MH Battery charger (1)
Power cord (mains lead) (1)
USB cable (1)
A/V connecting cable (1)
Wrist strap (1)
“Memory Stick” (16MB) (1)
CD-ROM (USB driver: SPVD-010) (1)
Operating Instructions (1)
Design and specifications are subject to change
without notice.
without notice.
x Camera
[System]
[System]
Image device 6.67 mm (1/2.7 type) color
CCD
Primary color filter
Primary color filter
Total pixels number of camera
Approx. 3 340 000 pixels
Effective pixels number of camera
Approx. 3 210 000 pixels
Lens
Exposure control
Automatic, Program, Twilight,
Twilight portrait, Landscape, Snow,
Beach
Twilight portrait, Landscape, Snow,
Beach
White balance Automatic, Daylight, Cloudy,
Fluorescent, Incandescent
File format (DCF compliant)
Still images: Exif Ver. 2.2, JPEG
compliant, GIF (for Clip Motion),
DPOF compatible
Audio with still image: MPEG1
compliant (Monaural)
Movies: MPEG1 compliant
(Monaural)
compliant, GIF (for Clip Motion),
DPOF compatible
Audio with still image: MPEG1
compliant (Monaural)
Movies: MPEG1 compliant
(Monaural)
2
×
zoom lens
f=6.3 to 12.6 mm
(35 mm camera conversion: 41 to
(35 mm camera conversion: 41 to
82 mm (1
5
/
8
to 3
1
/
4
inches))
F3.8
0.5 to 3.3 m (19
3
/
4
inches to
10 feet 9
29
/
32
inches)
123.2
×
57.7
×
52 mm
(4
7
/
8
×
2
3
/
8
×
2
1
/
8
inches)
Approx. 280 g (9.9 oz) (two
batteries, “Memory Stick” and wrist
strap included)
batteries, “Memory Stick” and wrist
strap included)
— 3 —
DSC-P52
1.
Check the area of your repair for unsoldered or poorly-soldered
connections. Check the entire board surface for solder splashes
and bridges.
connections. Check the entire board surface for solder splashes
and bridges.
2.
Check the interboard wiring to ensure that no wires are
"pinched" or contact high-wattage resistors.
"pinched" or contact high-wattage resistors.
3.
Look for unauthorized replacement parts, particularly
transistors, that were installed during a previous repair. Point
them out to the customer and recommend their replacement.
transistors, that were installed during a previous repair. Point
them out to the customer and recommend their replacement.
4.
Look for parts which, through functioning, show obvious signs
of deterioration. Point them out to the customer and
recommend their replacement.
of deterioration. Point them out to the customer and
recommend their replacement.
5.
Check the B+ voltage to see it is at the values specified.
6.
Flexible Circuit Board Repairing
• Keep the temperature of the soldering iron around 270˚C
during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
SAFETY CHECK-OUT
After correcting the original service problem, perform the following
safety checks before releasing the set to the customer.
Checking supplied accessories.
Make sure that the following accessories are supplied with your camcorder.
Battery charger (BC-CS2)(1)
(US,CND,JE model)
(US,CND,JE model)
0
1-477-814-11
Battery charger (BC-CS2)(1)
(AEP,UK,E,HK,AUS,BR model)
(AEP,UK,E,HK,AUS,BR model)
0
1-477-814-21
Battery charger (BC-CS2)(1)
(CH, KR model)
(CH, KR model)
0
1-477-814-32
Memory stick (1)
(MSA-16A)
(not supplied)
(MSA-16A)
(not supplied)
Hand strap (1)
3-070-841-01
3-070-841-01
Connection cord
(AV Cable 1.5m)(1)
1-824-111-11
(AV Cable 1.5m)(1)
1-824-111-11
CD-ROM (USB DRIVER) (1)
(SPVD-010)
(AEP,UK,E,HK,AUS,
CH,JE,KR,BR model)
3-078-942-03
CD-ROM (USB DRIVER) (1)
(SPVD-010 (I)) (US,CND model)
3-078-943-03
(SPVD-010)
(AEP,UK,E,HK,AUS,
CH,JE,KR,BR model)
3-078-942-03
CD-ROM (USB DRIVER) (1)
(SPVD-010 (I)) (US,CND model)
3-078-943-03
2P conversion adaptor (1)
(JE model)
1-569-007-12
(JE model)
1-569-007-12
2P conversion adaptor (1)
(E model)
1-569-008-12
(E model)
1-569-008-12
Note :
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Note :
Les composants identifiés par
une marque 0 sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce portant le numéro spécifié.
Les composants identifiés par
une marque 0 sont critiques
pour la sécurité.
Ne les remplacer que par une
pièce portant le numéro spécifié.
Cord with connector (1)
(USB 5P)
1-827-038-11
(USB 5P)
1-827-038-11
• Abbreviation
CND : Canadian model
HK
HK
: Hong Kong model
AUS : Australian model
CH
CH
: Chinese model
Battery carrying case (1)
3-074-757-01
3-074-757-01
JE
: Tourist model
KR
: Korea model
BR
: Brazilian model
HR6 (size AA) Ni-MH
batteries
(not supplied)
batteries
(not supplied)
Other accessories
3-082-146-11 MANUAL, INSTRUCTION (ENGLISH)
(US,CND,AEP,UK,E,HK,AUS,CH,JE)
3-082-146-21 MANUAL, INSTRUCTION (FRENCH/GERMAN)
(CND,AEP,JE)
3-082-146-31 MANUAL, INSTRUCTION (SPANISH/PORTUGUESE)
(AEP,E,JE)
3-082-146-41 MANUAL, INSTRUCTION (ITALIAN/DUTCH) (AEP)
3-082-146-51 MANUAL, INSTRUCTION (CHINESE) (E,HK,CH,JE)
3-082-146-61 MANUAL, INSTRUCTION (RUSSIAN/SWEDISH) (AEP,JE)
3-082-146-71 MANUAL, INSTRUCTION (ARABIC) (E)
3-082-146-81 MANUAL, INSTRUCTION (KOREAN) (KR,JE)
3-082-146-61 MANUAL, INSTRUCTION (RUSSIAN/SWEDISH) (AEP,JE)
3-082-146-71 MANUAL, INSTRUCTION (ARABIC) (E)
3-082-146-81 MANUAL, INSTRUCTION (KOREAN) (KR,JE)
Power cord (1)(AUS model)
0
1-696-819-21
Power cord (1)(AEP,E model)
0
1-769-608-11
Power cord (1)(CH model)
0
1-782-476-13
Power cord (1)(KR model)
0
1-776-985-11
Power cord (1)(UK,HK model)
0
1-783-374-11
Power cord (1)(US,CND model)
0
1-790-107-22
Power cord (1)(JE model)
0
1-790-732-12
— 4 —
DSC-P52
SELF-DIAGNOSIS FUNCTION
COVER
COVER
Note : The error code is cleared if the battery is removed, except defective flash unit.
*1: The error display is given in two ways.
Display Code
C:32:01
C:13:01
E:61:00 *1
E:61:10 *1
E:91:01
Countermeasure
Turn off the main power then back on.
Replace the memory stick.
Format the memory stick with the DSC-P52.
Format the memory stick with the DSC-P52.
Checking of lens drive circuit
Checking of flash unit or replacement of
flash unit.
flash unit.
Cause
Trouble with hardware.
• The type of memory stick that cannot be
used by this machine, is inserted.
• Data is damaged.
• Unformatted memory stick is inserted.
• Unformatted memory stick is inserted.
When failed in the focus initialization.
Abnormality when flash is being
charged.
charged.
Caution Display During Error
SYSTEM ERROR
MS ERROR
—
Flash LED
Flash display
Flashing at 3.2 Hz
Flash display
Flashing at 3.2 Hz
Self-diagnosis display
• C: ss: ss
• C: ss: ss
The contents which can be handled
by customer, are displayed.
by customer, are displayed.
• E: ss: ss
The contents which can be handled
by engineer, are displayed.
by engineer, are displayed.
[Description on Self-diagnosis Display]