CDX-V4800 - Sony Car Audio Service Manual (repair manual)

cdx-v4800 service manual
Model
CDX-V4800
Pages
48
Size
6.7 MB
Type
PDF
Document
Service Manual
Brand
Device
Car Audio
File
cdx-v4800.pdf
Date

Read Sony CDX-V4800 Service Manual online

SERVICE MANUAL
Sony Corporation
eVehicle Division
Published by Sony Techno Create Corporation
E Model
Chinese Model
FM/MW/SW MULTI MEDIA DISC PLAYER
9-887-262-02
2007A04-1
© 2007.01
Ver. 1.1  2007.01
SPECIFICATIONS
CDX-V4800
CD player section
Signal-to-noise ratio
90 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Signal format system
PAL/NTSC
Tuner section
FM
Tuning range
FM tuning interval:
50 kHz/200 kHz
switchable
87.5 – 108.0 MHz
(at 50 kHz step)
87.5 – 107.9 MHz
(at 200 kHz step)
Aerial terminal
External aerial connector
Intermediate frequency
10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
MW
Tuning range
531 – 1,602 kHz
(at 9 kHz step)
530 – 1,710 kHz
(at 10 kHz step)
MW tuning interval
9 kHz/10 kHz switchable
Aerial terminal
External aerial connector
Intermediate frequency
10.7 MHz/450 kHz
Sensitivity
30 
µV
SW
Tuning range
SW1: 2,940 – 7,735 kHz
SW2: 9,500 – 18,135 kHz
(except for 10,140 – 11,575 kHz)
Aerial terminal
External aerial connector
Intermediate frequency
10.7 MHz/450 kHz
Sensitivity
30 
µV
Power amplifier section
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 52 W 
× 4 (at 4 ohms)
• The tuner and CD sections have no adjustments.
Model Name Using Similar Mechanism
CDX-V6800
CD Drive Mechanism Type
MG-611MM-186//Q
Optical Pick-up Name
KSS1000E
– Continued on next page –
2
CDX-V4800
SAFETY-RELATED  COMPONENT  WARNING!!
COMPONENTS  IDENTIFIED  BY  MARK  0  OR  DOTTED  LINE
WITH  MARK  
0  ON  THE  SCHEMATIC  DIAGRAMS  AND  IN
THE  PARTS  LIST  ARE  CRITICAL  TO  SAFE  OPERATION.
REPLACE  THESE  COMPONENTS  WITH  SONY  PARTS
WHOSE  PART  NUMBERS  APPEAR  AS  SHOWN  IN  THIS
MANUAL  OR  IN  SUPPLEMENTS  PUBLISHED  BY  SONY.
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pick-
up block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged
by heat.
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical pick-
up block.
optical pick-up
semi-fixed resistor
SERVICE NOTES
E, Indian model
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
TEST DISCS
Please use the following test discs for the check on the voltage and
the waveforms of the CD section.
YDES-18 (Part No. 3-702-101-01)
PATD-012 (Part No. 4-225-203-01)
This label is located on the bottom of the chassis.
Chinese model
General
Outputs
Audio outputs terminal
(front, sub/rear switchable)
Video output terminal
Power aerial relay control terminal
Power amplifier control terminal
Inputs
Parking break control terminal
Aerial input terminal
AUX input jack (stereo mini jack)
Tone controls
Low: 
±10 dB at 60 Hz (XPLOD)
Mid: 
±10 dB at 1 kHz (XPLOD)
High: 
±10 dB at 10 kHz (XPLOD)
Power requirements
12 V DC car battery (negative earth)
Dimensions
Approx. 178 
× 50 × 179 mm (w/h/d)
Mounting dimensions
Approx. 182 
× 53 × 161 mm (w/h/d)
Mass
Approx. 1.2 kg
Supplied accessories
Parts for installation and connections (1 set)
Card remote commander RM-X158
Design and specifications are subject to change without
notice.
Ver. 1.1
3
CDX-V4800
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the lead-
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size.)
 : LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40
°C higher than
ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350
°C.
Caution: The printed pattern (copper foil) may peel away if the
heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
Notes on CD-Rs (recordable CDs)/CD-RWs (rewritable
CDs)
This unit can play the following discs:
Type of discs
Label on the disc
Audio CD
MP3 files
• Some CD-Rs/CD-RWs (depending on the equipment used for
its recording or the condition of the disc) may not play on this
unit.
• You cannot play a CD-R/CD-RW that is not finalized*.
• You can play MP3 files recorded on CD-ROMs, CD-Rs, and
CD-RWs.
• A CD-R/CD-RW to which a session can be added can be played.
* A process necessary for a recorded CD-R/CD-RW disc to be
played on the audio CD player.
Notes on Video CDs
This unit can play the following discs:
Type of discs
Label on the disc
Video CD
VCD
A compact disc that contains moving pictures.
The picture data uses the MPEG 1 format (Video CD), worldwide
standards of digital compression technology.
Video CDs also contain compact audio data.
Sounds outside the range of human hearing are compressed while
the sounds we can hear are not compressed.
4
CDX-V4800
TABLE OF CONTENTS
1.
GENERAL
Location of Controls ........................................................
5
Connections .....................................................................
5
2.
DISASSEMBLY
2-1.
Sub Panel Assy ................................................................
9
2-2.
CD Mechanism Block .....................................................
9
2-3.
Main Board ...................................................................... 10
2-4.
Chassis (T) Sub Assy ....................................................... 10
2-5.
Roller Arm Assy .............................................................. 11
2-6.
Chassis (OP) Assy ........................................................... 11
2-7.
Optical Pick-up ................................................................ 12
2-8.
SL Motor Assy (M902) ................................................... 12
2-9.
LE Motor Assy (M903) ................................................... 13
2-10. Servo Board ..................................................................... 13
3.
DIAGRAMS
3-1.
Block Diagram –CD Section– ......................................... 15
3-2.
Block Diagram –Main Section– ...................................... 16
3-3.
Block Diagram –Key Section– ........................................ 17
3-4.
Circuit Boards Location .................................................. 17
3-5.
Printed Wiring Boards –CD Mechanism Section– .......... 19
3-6.
Schematic Diagram –CD Mechanism Section (1/2)– ..... 20
3-7.
Schematic Diagram –CD Mechanism Section (2/2)– ..... 21
3-8.
Printed Wiring Boards –Main Section– ........................... 22
3-9.
Schematic Diagram –Main Section (1/3)– ...................... 23
3-10. Schematic Diagram –Main Section (2/3)– ...................... 24
3-11. Schematic Diagram –Main Section (3/3)– ...................... 25
3-12. Printed Wiring Boards –Key Section– ............................. 26
3-13. Schematic Diagram –Key Section– ................................. 27
4.
EXPLODED VIEWS
4-1.
Main Section .................................................................... 34
4-2.
Front Panel Section ......................................................... 35
4-3.
CD Mechanism Section (1) ............................................. 36
4-4.
CD Mechanism Section (2) ............................................. 37
4-5.
CD Mechanism Section (3) ............................................. 38
4-6.
CD Mechanism Section (4) ............................................. 39
5.
ELECTRICAL PARTS LIST
.................................. 40
Page of 48
Display

Download Sony CDX-V4800 Service Manual (Repair Manual)

Here you can read online and download Sony CDX-V4800 Service Manual in PDF. CDX-V4800 service manual will guide through the process and help you recover, restore, fix, disassemble and repair Sony CDX-V4800 Car Audio. Information contained in service manuals typically includes schematics / circuit diagrams, wiring diagrams, block diagrams, printed wiring boards, exploded views, parts list, disassembly / assembly, pcb.