CDX-R30M, CDX-R3310, CDX-R3410, CDX-R3410S - Sony Car Audio Service Manual (repair manual)

cdx-r30m, cdx-r3310, cdx-r3410, cdx-r3410s service manual
Model
CDX-R30M CDX-R3310 CDX-R3410 CDX-R3410S
Pages
47
Size
4.57 MB
Type
PDF
Document
Service Manual
Brand
Device
Car Audio
File
cdx-r30m-cdx-r3310-cdx-r3410-cdx-r3410s.pdf
Date

Read Sony CDX-R30M / CDX-R3310 / CDX-R3410 / CDX-R3410S Service Manual online

1
Ver. 1.0  2005.01
Model Name Using Similar Mechanism
NEW
CD Drive Mechanism Type
MG-611TA-186//Q
Optical Pick-up Name
KSS1000E
SERVICE MANUAL
US Model
CDX-R30M
Canadian Model
CDX-R3310
E Model
CDX-R3410/R3410S
SPECIFICATIONS
• The tuner and CD sections have no adjustments.
Sony Corporation
e Vehicle Company
Published by Sony Engineering Corporation
9-879-386-01
2005A04-1
© 2005. 01
– Continued on next page –
FM/AM COMPACT DISC PLAYER
AUDIO POWER SPECIFICATIONS (US MODEL)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23.2 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
CD player section
Signal-to-noise ratio
120 dB
Frequency response
10 – 20,000 Hz
Wow and flutter
Below measurable limit
Tuner section
FM
Tuning range
CDX-R3310:
87.5 – 107.9 MHz
CDX-R30M/R3410/R3410S:
87.5 – 108.0 MHz (at 50 kHz step)
87.5 – 107.9 MHz (at 200 kHz step)
FM tuning interval
50 kHz/200 kHz switchable
(CDX-R30M/R3410/R3410S)
Antenna terminal
External antenna connector
Intermediate frequency
10.7 MHz/450 kHz
Usable sensitivity
9 dBf
Selectivity
75 dB at 400 kHz
Signal-to-noise ratio
67 dB (stereo),
69 dB (mono)
Harmonic distortion at 1 kHz
0.5% (stereo),
0.3% (mono)
Separation
35 dB at 1 kHz
Frequency response
30 – 15,000 Hz
AM
Tuning range
CDX-R3310:
530 – 1,710 kHz
CDX-R30M/R3410/R3410S:
531 – 1,602 kHz (at 9 kHz step)
530 – 1,710 kHz (at 10 kHz step)
AM tuning interval
9 kHz/10 kHz switchable
(CDX-R30M/R3410/R3410S)
Antenna terminal
External antenna connector
Intermediate frequency
10.7 MHz/450 kHz
Sensitivity
30 µV
Power amplifier section
Outputs
Speaker outputs
(sure seal connectors)
Speaker impedance
4 – 8 ohms
Maximum power output 52 W 
×
 4 (at 4 ohms)
General
Outputs
Audio outputs terminal
(sub/rear switchable)
Power antenna relay control terminal
Power amplifier control terminal
Inputs
BUS control input terminal
BUS audio input terminal
Remote controller input terminal
Antenna input terminal
CDX-R30M/R3310/
R3410/R3410S
2
CDX-R30M/R3310/R3410/R3410S
If the optical pick-up block is defective, please replace the whole
optical pick-up block.
Never turn the semi-fixed resistor located at the side of optical
pick-up block.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
breakdown because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic breakdown and also use
the procedure in the printed matter which is included in the repair
parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pick-
up block. Therefore, when checking the laser diode emission, ob-
serve from more than 30 cm away from the objective lens.
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
TEST DISCS
This set can playback CD-R and CD-ROM discs. The following
test discs should be used to check the capability:
CD-R test disc TCD-R082LMT (Part No. J-2502-063-1)
CD-RW test disc TCD-W082L (Part No. J-2502-063-2)
SERVICE NOTES
optical pick-up
semi-fixed resistor
This label is located on the bottom of the chassis.
Tone controls
Low: ±10 dB at 60 Hz (XPLOD)
Mid: ±10 dB at 1 kHz (XPLOD)
High: ±10 dB at 10 kHz (XPLOD)
Power requirements
12 V DC car battery
(negative ground)
Dimensions
Approx. 178 
×
 50 
×
 179 mm
(7 
1/8
 
×
 2 
×
 7 
1/8
 in.) (w/h/d)
Mounting dimensions
Approx. 182 
×
 53 
×
 161 mm
(7 
1/4
 
×
 2 
1/8
 
×
 6 
3/8
 in.) (w/h/d)
Mass
Approx. 1.2 kg (2 lb 10 oz)
Supplied accessories
Parts for installation and connections (1 set)
Front panel case (1)
Card remote commander RM-X151
US and foreign patents licensed from Dolby Laboratories.
Note
This unit cannot be connected to a digital preamplifier or an equalizer which is Sony
BUS system compatible.
Design and specifications are subject to change without
notice.
SAFETY-RELATED  COMPONENT  WARNING!!
COMPONENTS  IDENTIFIED  BY  MARK  
0
  OR  DOTTED  LINE
WITH  MARK  
0
  ON  THE  SCHEMATIC  DIAGRAMS  AND  IN
THE  PARTS  LIST  ARE  CRITICAL  TO  SAFE  OPERATION.
REPLACE  THESE  COMPONENTS  WITH  SONY  PARTS  WHOSE
PART  NUMBERS  APPEAR  AS  SHOWN  IN  THIS  MANUAL  OR
IN  SUPPLEMENTS  PUBLISHED  BY  SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
 À LA SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 
0
 SUR LES
DIAGRAMMES SCHÉMATIQUES ET LA LISTE  DES PIÈCES
SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT.
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES
SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL
OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
• CDX-R3410/R3410S only.
3
CDX-R30M/R3310/R3410/R3410S
• CD Playback:
You can play CD-DA (also containing CD TEXT*
1
), CD-R/CD-
RW (MP3 files also containing Multi Session and ATRAC CD
(ATRAC3 and ATRAC3plus format).
Type of discs
Label on the disc
CD-DA
MP3
ATRAC CD
*1 A CD TEXT disc is a CD-DA that includes information such as
disc, artist and track name.
EXTENSION CABLE AND SERVICE POSITION
When repairing or servicing this set, connect the jig (extension cable)
as shown below.
• Connect the MAIN board (CNP301) and the SERVO board (CN2)
with the extension cable (Part No. J-2502-076-1).
z
 UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the lead
free mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40 °C higher
than ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 °C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscou-s (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
SERVO BOARD
CN2
J-2502-076-1
MAIN BOARD
CNP301
4
TABLE OF CONTENTS
1. GENERAL
Location of Controls ................................................................ 5
Connections ............................................................................. 6
2. DISASSEMBLY
2-1.   Sub Panel Assy (CD) ......................................................... 10
2-2.   CD Mechanism Block ....................................................... 10
2-3.   Main Board ....................................................................... 11
2-4.   Chassis (T) Sub Assy ........................................................ 11
2-5.   Roller Arm Assy ................................................................ 12
2-6.   Chassis (OP) Assy ............................................................. 12
2-7.   Optical Pick-up ................................................................. 13
2-8.   SL Motor Assy (M902) ..................................................... 13
2-9.   LE Motor Assy (M903) ..................................................... 14
2-10. Servo Board ....................................................................... 14
3. DIAGRAMS
3-1.   Block Diagram –CD Section– ........................................... 15
3-2.   Block Diagram –Main Section– ........................................ 16
3-3.   Block Diagram –Display Section– .................................... 17
3-4.   Circuit Boards Location .................................................... 17
3-5.   Printed Wiring Boards –CD Mechanism Section– ............ 19
3-6.   Schematic Diagram –CD Mechanism Section (1/2)– ....... 20
3-7.   Schematic Diagram –CD Mechanism Section (2/2)– ....... 21
3-8.   Printed Wiring Board –Main Section– .............................. 22
3-9.   Schematic Diagram –Main Section (1/3)– ........................ 23
3-10. Schematic Diagram –Main Section (2/3)– ........................ 24
3-11. Schematic Diagram –Main Section (3/3)– ........................ 25
3-12. Printed Wiring Board –Display Section– .......................... 26
3-13. Schematic Diagram –Display Section– ............................. 27
4. EXPLODED VIEWS
4-1.   Main Section ..................................................................... 35
4-2.   Front Panel Section ........................................................... 36
4-3.   CD Mechanism Section (1) ............................................... 37
4-4.   CD Mechanism Section (2) ............................................... 38
4-5.   CD Mechanism Section (3) ............................................... 39
4-6.   CD Mechanism Section (4) ............................................... 40
5. ELECTRICAL PARTS LIST
........................................ 41
CDX-R30M/R3310/R3410/R3410S
Page of 47
Display

Download Sony CDX-R30M / CDX-R3310 / CDX-R3410 / CDX-R3410S Service Manual (Repair Manual)

Here you can read online and download Sony CDX-R30M / CDX-R3310 / CDX-R3410 / CDX-R3410S Service Manual in PDF. CDX-R30M / CDX-R3310 / CDX-R3410 / CDX-R3410S service manual will guide through the process and help you recover, restore, fix, disassemble and repair Sony CDX-R30M / CDX-R3310 / CDX-R3410 / CDX-R3410S Car Audio. Information contained in service manuals typically includes schematics / circuit diagrams, wiring diagrams, block diagrams, printed wiring boards, exploded views, parts list, disassembly / assembly, pcb.