Read Sharp AR-C250 (serv.man98) Regulatory Data online
MATERIAL SAFETY DATA SHEET
Page:1/4
Date Issued :May. 1. 2001
MSDS NO. F-30928
1. PRODUCT AND COMPANY IDENTIFICATION
Product Name : AR-C15ND9/C15DV9/C15SD9 (Yellow Developer)
Supplier Identification : Sharp Corporation
Supplier Identification : Sharp Corporation
22-22 Nagaike-cho, Abeno-ku, Osaka, Japan
Local suppliers are listed below. Please contact the nearest supplier for additional information.
(Country)
(Name and Telephone Number)
U.S.A.
Sharp Electronics Corporation
Telephone number for information : 1-800-237-4277
Emergency telephone number : 1-800-255-3924
Telephone number for information : 1-800-237-4277
Emergency telephone number : 1-800-255-3924
Canada
Sharp Electronics of Canada Ltd.
Telephone number for information : 905-890-2100
Emergency telephone number : 1-800-255-3924
Telephone number for information : 905-890-2100
Emergency telephone number : 1-800-255-3924
United
Kingdom
Sharp Electronics (U. K.) Ltd.
Telephone number for information : 01923-47-4013
Telephone number for information : 01923-47-4013
Australia
Sharp Corporation of Australia PTY. Ltd.:
Telephone number for information : 1300-13-50-22
Telephone number for information : 1300-13-50-22
Germany
Sharp Electronics (Europe) GMBH
Telephone number for information : 40-2376-2737
Telephone number for information : 40-2376-2737
2.COMPOSITION/INFORMATION ON INGREDIENTS
Substance[ ] Preparation[X]
Ingredient CAS
No. Proportion OSHA
PEL ACGIH
TLV DFG-MAK NOHSC-
TWA
Ferrite
92-99%
Not listed
Not listed
Not listed
Not listed
Manganese oxide
1344-43-0
Magnesium oxide
1309-48-4
Strontium oxide
1314-11-0
Iron oxide
1309-37-1
Polyester resin
75214-60-7
1-8%
Not listed
Not listed
Not listed
Not listed
Carbon black
1333-86-4
<1%
3.5mg/m
3
3.5mg/m
3
Not listed
3mg/m
3
3.HAZARDS IDENTIFICATION
Most Important Hazards and Effects of the Products
Human Health Effects : There are no anticipated carcinogenic effects from exposure based on animal tests
performed using toner. When used as intended according to instructions, studies do not
indicate any symptoms of fibrosis will occur.
indicate any symptoms of fibrosis will occur.
Environmental Effects : No data are available.
Specific hazards : None
4.FIRST-AID MEASURES
Route(s) of Entry : Inhalation?
Skin?
Ingestion?
No
No
Possible but very unusual.
Inhalation
: Remove to fresh air. If symptoms occur, consult medical personnel.
Skin Contact : Wash with soap and water for 15 minutes or until particle is removed.
If irritation does occur, consult medical personnel.
Eye Contact
: Flush eyes immediately with water for 15 minutes. If irritation does occur, consult medical personnel.
Ingestion
: Rinse with water and drink several glasses of water . If irritation or discomfort does occur, consult
medical personnel.
MATERIAL SAFETY DATA SHEET
Page:2/4
Date Issued :May. 1. 2001
MSDS NO. F-30928
5.FIRE –FIGHTING MEASURES
Extinguishing Media : water , CO2, foam and dry chemicals
Special Fire fighting Procedures : None
Fire and Explosion Hazards : Like most finely divided organic powders, it may form an explosive mixture.
6.ACCIDENTAL RELEASE MEASURES
Personal Precautions : None
Environmental Precautions : None
Methods for Cleaning Up : Wipe off with paper or cloth. DO not use vacuum cleaner when a large amount is
released. It, like most finely divided organic powders, is capable of creating
a dust explosion.
7.HANDLING AND STORAGE
Handling
Technical Measures : None
Precautions : None
Precautions : None
Safe Handling Advice : Use of a dust mask is recommended when handling a large quantity of toner or during long
term exposure, as with any non-toxic dust. Try not to disperse the particles.
Storage
Technical Measures : None
Storage Conditions : Keep container closed and Store in a cool and dry place.
Storage Conditions : Keep container closed and Store in a cool and dry place.
Keep out of the reach of children.
Incompatible Products : None
8.EXPOSURE CONTROL
/
/
/
/PERSONAL PROTECTION
Engineering Measures
Ventilation : None required with intended use.
Exposure limit values
OSHA-PEL(USA) : 15mg/m3 (Total Dust) , 5mg/m3 (Respirable Dust)
ACGIH-TLV(USA) : 10mg/m3(Total Dust) , 3mg/m3 (Respirable Dust)
Personal Protective Equipment
Respiratory Protection : None required when used as intended in Sharp equipment.
Hand Protection : None required when used as intended in Sharp equipment.
Eye Protection : None required when used as intended in Sharp equipment.
Skin Protection : None required when used as intended in Sharp equipment.
Other Protective equipment : Use of a dust mask and goggles are recommended when handling a large quantity of
toner or during long term exposure, as with any non-toxic dust.
9.PHYSICAL AND CHEMICAL PROPERTIES
Appearance
Physical State : Solid Form: Powder Color: Dark yellow Odor: odorless
Ph : Not applicable
Boiling/Melting Point : Not applicable
Flash Point(°C ) : Not applicable
Explosion Properties : No data
Density(g/cm³) : Approx.5.0 (bulk density : Approx.2.1)
Solubility in water : Negligible
MATERIAL SAFETY DATA SHEET
Page:3/4
Date Issued :May. 1. 2001
MSDS NO. F-30928
10.STABILITY AND REACTIVITY
Stability : Stable
Hazardous Reactions : Dust explosion, like most finely divided organic powders.
Conditions to avoid : Electric discharge, throwing into fire.
Materials to avoid : Oxidizing Materials
Hazardous Decomposition Products : CO, CO2 and NOX
Further Information : None
11.TOXICOLOGICAL INFORMATION
Acute Toxicity
Ingestion(oral) : LDL
0
>2000mg/kg(Rats)
Dermal : No Data
Inhalation : No Data
Eye irritation : Not an irritant(Rabbits)
Skin irritation : Not an irritant(Rabbits)
Skin sensitizer : No Data
Eye irritation : Not an irritant(Rabbits)
Skin irritation : Not an irritant(Rabbits)
Skin sensitizer : No Data
Mutagenicity : Negative(Ames Test)
Carcinogenicity :In 1996 the IARC reevaluated carbon black as a Group 2B carcinogen (possible
human
carcinogen). This classification is given to chemicals for which there is inadequate human
evidence, but sufficient animal evidence on which to base an opinion of carcinogenicity. The
classification is based upon the development of lung tumors in rats receiving chronic inhalation
exposures to free carbon black at levels that induce particle overload of the lung. Studies
performed in animal models other than rats did not show any association between carbon black
and lung tumors. Moreover, a two-year cancer bioassay using a typical toner preparation
containing carbon black demonstrated no association between toner exposure and tumor
development in rats.
evidence, but sufficient animal evidence on which to base an opinion of carcinogenicity. The
classification is based upon the development of lung tumors in rats receiving chronic inhalation
exposures to free carbon black at levels that induce particle overload of the lung. Studies
performed in animal models other than rats did not show any association between carbon black
and lung tumors. Moreover, a two-year cancer bioassay using a typical toner preparation
containing carbon black demonstrated no association between toner exposure and tumor
development in rats.
Chronic Effect
: In a study in rats of chronic inhalation exposure to a typical toner, a mild to moderate degree of lung
fibrosis was observed in 92% of the rats in the high concentration (16mg/m
3
) exposure group, and
a minimal to mild degree of fibrosis was noted in22% of the animals in the middle (4mg/m
3
)
exposure group, but no pulmonary change was reported in the lowest (1mg/m
3
) exposure group,
the most relevant level to potential human exposures.
12.ECOLOGICAL INFORMATION
No data are available.
13.DISPOSAL CONSIDERATION
Waste from residues :
Waste material may be dumped or incinerated under conditions which meet all federal,
state and local environmental regulations.
Contaminated Packaging : Waste may be disposed or incinerated under conditions which meet all federal, state and
local environmental regulations.
MATERIAL SAFETY DATA SHEET
Page:4/4
Date Issued :May. 1. 2001
MSDS NO. F-30928
14.TRANSPORT INFORMATION
UN Classification : None
Land DOT(USA) : Not dangerous substance
Sea IMDG : Not applicable
Air ICAO-TI : Not applicable
Air ICAO-TI : Not applicable
15.REGULATORY INFORMATION
US Information
TSCA(Toxic Substances Control Act) :
All chemical substances in this product comply with all applicable rules or order under TSCA.
SARA(Superfund Amendments and Reauthorization Act) Title III
302 Extreme Hazardous Substance: None
311/312 Hazard Classification : None
EU Information
1999/45/EC and 67/548/EEC
Symbol & Indication : Not required
R-Phrase : Not required
R-Phrase : Not required
76/769/EEC : All chemical substances in this product comply with all applicable rules or order under 76/769/EEC.
16.OTHER INFORMATION
NFPA Rating
(USA) : Health=1 Flammability=1 Reactivity=0
WHMIS Legislation (Canada) : This product is not a controlled product.
References
IARC(1996) : IARC monographs on the Evaluation of the Carcinogenic Risk of Chemicals to Humans, Vol. 65,
Printing Process And Printing Inks, Carbon Black and Some Nitro Compounds, Lyon, pp.149-261
H.Muhle, B.Bellmann, O.Creutzenberg, C.Dasenbrock, H.Ernst, R.Kilpper, J.C.MacKenzie, P.Morrow, U.Mohr,
S.Takenaka, and R.Mermelstein(1991) Pulmonary Response to Toner upon Chronic Inhalation Exposure in Rats.
Fundamental and Applied Toxicology 17, pp.280-299.
The information on this data sheet represents our current data and best opinion as to the proper use in handling of this
product under normal conditions. However, all materials may present unknown hazards and should be used with caution.
Although certain hazards are described herein, we do not guarantee that these are the only hazards which exist.