Read Sharp R-953 (serv.man12) Technical Bulletin online
MWO2001 02 03
Month of Issue:
August 2002
Classification:
White
MICROWAVE TECHNICAL BULLETIN
Page 1 of 2
Sharp Electronics (UK) Limited
Reference TBM0102278
Revision 3
White – Carry out as required
Yellow – Carry out as required and whenever the unit comes in for service
Red – Carry out on all units
MODELS
R953M
R963M
SYMPTOM Oven cavity does not reach the desired temperature during convection cooking.
Note that the oven convection cooking temperature should be within +/- 15
O
C of the
set temperature
.
REASON
Various problems can cause poor convection cooking performance. Refer to the list
below, detailing items to check.
below, detailing items to check.
ACTION
Confirm the general build and functional performance of the oven as follows:-
◊
Check the damper door open/close mechanism for correct operation
◊
Confirm that the convection and fan motors operate freely and without restriction
◊
Confirm that none of the internal fuses have blown
◊
Check the alignment of the door (heat loss)
◊
Check for correct operation of the thermistor
◊
Check the value of R81, if 0 ohm replace with 1K ohm
1
/
10
W (SMD)
If the above checks are good, fit a washer to the underside of the thermistor on the
cavity top plate, as shown in figures below. This will de-sensitise the thermistor by
slightly pulling it out of the cavity.
cavity top plate, as shown in figures below. This will de-sensitise the thermistor by
slightly pulling it out of the cavity.
Use the part number listed on the next page for the washer. It is important that the
correct washer is fitted.
correct washer is fitted.
MWO2001 02 03
Month of Issue:
August 2002
Classification:
White
MICROWAVE TECHNICAL BULLETIN
Page 2 of 2
Sharp Electronics (UK) Limited
Reference TBM0102278
Revision 3
White – Carry out as required
Yellow – Carry out as required and whenever the unit comes in for service
Red – Carry out on all units
REF NO
DESCRIPTION
PART NUMBER
PRICE CODE
-
Washer (0.8mm)
XWHUW40-08000
AA
R81
1k ohm resistor
VRS-CY1JF102F
AA
Display