KX-FP300E - Panasonic Fax Service Manual Simplified (repair manual)

1

(Model KX-FP300E)

KX-FP300E

Please use this manual together with the Service Manual for model No. KX-FP300G, order No.KM79906283C2.

This Service Manual indicates the main differences between; Original KX-FP300G and KX-FP300E.

ORDER NO. KM79907296A2

Compact Plain Paper FAX

(for United Kingdom)

2

(Model KX-FP300E)

2. Program Mode Table (Change from original page 63.)

001

Set date and time

dd/mm/yy hh:mm

01/Jan/99

NG

002

Your logo

 --------- 

None

NG

003

Your FAX number

 --------- 

None

NG

004

Print sending report

1:Error / 2:ON /  3:OFF

Error

OK

007

FAX ring count

1 to 5 rings (for ext. tam)

2

OK

012

Remote TAM activation

ON / OFF

OFF/ID=11

NG

013

Dialing mode

1:Pulse / 2:Tone

Tone

OK

015

Send by memory

1:ON  / 2:OFF

OFF

OK

022

Journal auto print

1:ON  / 2:OFF

ON

OK

023

Overseas mode

ON / OFF

OFF

NG

025

Delayed transmission

ON / OFF

OFF

NG

026

Auto  caller id list

ON / OFF

ON

OK

030

Silent FAX recognition ring

3 to 6 rings

3

OK

036

Rx reduction

1:92% / 2:86% / 3:72% / 4:OFF

92%

OK

039

LCD contrast

1:Normal / 2:Darker

Normal

OK

040

Silent detection

1:ON  / 2:OFF

ON

OK

041

Remote FAX activation code

ON  / OFF

ON ID=*9

NG

044

Receive alert

1:ON  / 2:OFF

ON

OK

046

Friendly reception

1:ON  / 2:OFF

ON

OK

068

Ecm communication

1:ON  / 2:OFF

ON

OK

076

Connection tone

1:ON  / 2:OFF

ON

OK

077

Auto answer mode

1:TEL / FAX  2:  FAX Only

FAX ONLY

OK

079

Film detection

1:ON  / 2:OFF

ON

OK

080

Set default

YES / NO

NO

NG

502

Flash time

01~99 x 10msec

080

OK

503

Dial speed

1:10pps  / 2:20 pps

10pps

OK

511

Vox senes

1:High / 2:Low

High

OK

520

CED frequency

1:2100Hz  / 2:1100Hz

2100

OK

522

Auto standby

1:ON  / 2:OFF

ON

OK

551

ROM check

 --------- 

 --------- 

NG

552

DTMF signal tone test

ON  / OFF

OFF

NG

553

Monitor on FAX communication

1:OFF  / 2:Phase B  / 3:ALL

OFF

OK

554

Modem test

 --------- 

 --------- 

NG

555

Scanner test

 --------- 

 --------- 

NG

556

Motor test

 --------- 

 --------- 

NG

557

LED test

 --------- 

 --------- 

NG

558

LCD test

 --------- 

 --------- 

NG

559

Document jam detection

1:ON  / 2:OFF

ON

OK

561

Key test

 --------- 

 --------- 

NG

563

CCD position adjustment

00~30

 --------- 

OK

3

(Model KX-FP300E)

OK means "can set".
NG means "can not set".

NOTE:
      Refer to 2.4.4. SERVICE FUNCTION TABLE for descriptions of the individual codes.
Example:
       If you want to set value in the "004 Transmission report mode", press the dial key number 1, 2 or 3 corresponding to the
      Set Value you want to select. (1: ERROR / 2: ON / 3: OFF)

592

CNG transmit select

1:OFF /  2:ALL / 3:AUTO

ALL

OK

593

Time between CED and 300 bps

1:75ms  / 2:500ms  / 3:1sec

75ms

OK

594

Overseas DIS detection

1:1st  / 2:2nd

1st

OK

701

No voice detect time

01~99

40x100msec

OK

717

Transmit speed select

1:9600/ 2:7200/ 3:4800/ 4:2400

9600bps

OK

718

Receive speed select

1:9600/ 2:7200/ 3:4800/ 4:2400

9600bps

OK

719

Ringer off in TEL/FAX mode

1:ON  / 2:OFF

ON

OK

771

T1 timer

1:35s / 2:60s

35s

OK

815

Sensor & VOX test

 --------- 

 --------- 

NG

852

Print test pattern

 --------- 

 --------- 

NG

853

Top margin

1~9

5

OK

854

Left margin

1~8

5

OK

861

A4 size set

1:ON /  2:OFF

ON

OK

880

Special journal

1:Start

 --------- 

NG

890

TEL/FAX ring back tone

1:ON /  2:OFF

ON

OK

991

Setup list

1:Start

 --------- 

OK

994

Journal list

1:Start

 --------- 

OK

999

Service list

1:Start

 --------- 

OK

4

(Model KX-FP300E)

2.3.3.5.  Analog Board Section (Change from original page 75.)

This chapter provides the testing procedures required for the analog parts.  A signal route to be tested is determined
depending upon purposes.  For example, the handset TX route begins at the handset microphone and signal is output to the
telephone line.  The signal mainly flowing on this route is analog.  You can trace the signal with an oscilloscope.  The signal
flow on each route is shown in the Check Sheet here.  If you find a specific problem in the unit, for example if you cannot
communicate  with the H/S, trace that signal route locally with the following Check Sheet and locate the faulty point.

     (SYMPTOM)

ITEMS TO CHECK

ROUTE

I N

O U T

CHECK  SHEET

MONITOR Rx

DTMF

  monitor

Speaker

Handset

DTMF for TEL LINE

        FAX Tx

Dummy Ring

Back tone

RINGING

Alarm / Beep /
Key tone

FAX Rx

VOX

TEL LINE-T2-C115-R154-IC5(61-67)-C116-R151-IC5(68-70)-C154-D37-R182-IC15(2-1)

-R189-CN9(3)-{CN503(3)-R716-IC501(45)}

TEL LINE-T1-R59-C44-IC10(6-7)-J33-C56-C59-R85-R89-C64-IC2(1-2)-C68-

CN7(9)-{CN501(9)-C701-IC801(3-4)-C809-R810-IC803(6-7)-J607-C603-R617-IC517(2-1)-C596-R605-

IC505(45)}

{IC501(38)-R567-R573-C564-CN501(1)}-CN7(11)-R161-C119-IC5(77-41)-C100-R139-IC5(40-38)-C91-

R132-IC3(4-5,8)-SPEAKER

{IC501(39)-R565-R572-C631-CN502(1)}-CN8(1)-R162-C120-IC5(78-41)-C100-R139-IC5(40-38)-C91-

R132-IC3(4-5,8)-SPEAKER

{IC501(39)-R565-R572-C631-CN502(1)}-CN8(1)-R162-C120-IC5(78-63)-C53-R73-IC10(2-1)-C37-R58-R57-

T1-TEL LINE

{IC505(44)-C593-R610-IC517(6-7)-C604-CN501(10)}-CN7(10)-C126-R159-IC5(73-63)-C53-R73-

IC10(2-1)-C37-R58-R57-T1-TEL LINE

{IC505(44)-C593-R610-IC517(6-7)-C604-CN501(10)}-CN7(10)-C126-R155-IC5(76-45,46)

 

 C84-L37 

 Speaker

          L36

{IC505(44)-C593-R610-IC517(6-7)-C604-CN501(10)}-CN7(10)-C126-R155-IC5(76-41)-C100-R139-

IC5(40-38) -C91-R132-IC3(4-5,8)-Speaker

TEL LINE-T1-R59-C44-IC10(6-7)-J33-C56-C57-R80-R150-C113-IC5(59-41)-C100-

R139-IC5(40-38)-C91-R132-IC3(4-5,8)-Speaker

Signal

TEL LINE -T1-R59-C44-IC10(6-7)-J33-C56-C57-R80-R150-C113-IC5(59-45,56)

---C84-L37---SPEAKER

      L36

MIC---L35-R135-C94---IC5(52,54-63)-C53-R73-IC10(2-1)-C37-R58-R57-T1-TEL LINE

L38-R134-C93

Handset Rx

Handset Tx

DTMF detection

TEL LINE-T2-C115-R154-IC5(61-35)-R180-C150-IC4(1-5)-R174-IC5(25)

CNG detection

TEL LINE-T2-C115-R154-IC5(61-67)-R167-C134-IC2(10-11)-C68-CN7(9)-{CN501(9)-C701-IC801(3-4)-

C809-R810-IC803(6-7)-J607-C603-R617-IC517(2-1)-C596-R605-IC505(45)}

Caller ID

TEL LINE-T2-C115-R154-IC5(61-67)-R167-C134-IC2(10-11)-C68-CN7(9)-{CN501(9)-C701-IC801(1-2)-

J606-C807-R808-IC803(6-7)-J607-C603-R617-IC517(2-1)-C596-R605-IC505(45)}

(TONE 2)

(TONE 2)

(TONE 1)